バイオマスガス化とは、低カロリーのバイオマスエネルギー源を利用し、特定の反応条件下で酸化還元反応を経て、水素や一酸化炭素などの可燃性ガスを生成するプロセスです。この反応によって生成されたガスは、直接熱エネルギーを供給するために使用することも、電力を生産するために使用することもできます。

バイオマスエネルギーとは何ですか?

バイオマスエネルギーの源は太陽エネルギーです。バイオマスエネルギーは、微生物、植物、動物が光合成を通じて蓄積したエネルギーです。バイオマスエネルギーの源は非常に広範です。作物の straw、木材加工の廃棄物、動物の糞、都市の家庭ごみ、工業廃棄物(ゴム、プラスチック廃棄物など)が一般的なバイオマスエネルギーです。

バイオマスエネルギー
バイオマスエネルギー

バイオマスエネルギーの特徴は何ですか?

  1. Environmental protection: First of all, raw materials are all kinds of wastes, which solves the problem of disposal of some wastes. Secondly, after the oxidation-reduction reaction, the produced gas is carbon monoxide(CO), hydrogen(H2), methane(CH4), polyacetylene(CmHn) and other combustible gases, which does not cause any pollution to the environment.
  2. Renewable Energy: Biomass energy can be produced again through photosynthesis of plants and animals. It belongs to renewable energy as well as solar energy, water energy, wind energy, etc.
  3. The richness of the total amount: Biomass energy, as the fourth largest energy source on earth, has a wide range of sources. According to statistics, the biomass energy produced by the earth every year is about 10 times the energy consumed by human beings, while the utilization rate of such energy by human beings is less than 3%.
  4. Low production cost: The cost of recycling biomass waste is low, so the cost of using biomass energy to generate electricity is very low, close to 02-0.3RMB / Kw.H, which is equivalent to 60% -70% of the cost of using coal to generate electricity.

上記のバイオマスエネルギーの特性により、ますます多くの国がこのようなエネルギーの利用に注目し始めています。バイオマスエネルギーを使用して電力を供給したり、電気を生産することは、今後の発展のトレンドです。

バイオマスガス化の紹介

バイオマスエネルギーのガス化器における不完全燃焼と酸化還元反応の後、一連の可燃性ガスが生成されます。このプロセスはバイオマスエネルギーのガス化と呼ばれています。

作業プロセス

乾燥 → 熱分解 → 酸化 → 還元 → 精製 → 可燃性ガスの燃焼と利用

関連デバイス

ガス化装置-冷却ダストコレクター-タール精製装置-タール分離器-内燃機関/ボイラーなど。

ガス化プロセス

ガス化装置は主に5つの層に分かれています:空気層、乾燥層、熱分解層、酸化層、還元層。

ガス化炉内の反応
ガス化装置内の反応

バイオマス材料がガス化炉に入ると、乾燥し加熱されます。温度が上昇し続けると、揮発性物質が高温で沈殿し、熱分解反応を経ます。熱分解ガスと炭化物が反応して水蒸気と二酸化炭素を生成します。同時に、発生した熱は還元反応の吸熱還元やタールの熱分解に利用され、最適な熱利用が達成されます。

ガス化炉の機能
ガス化装置の機能

ガス化装置の底部にあるスパイラルコンベヤーからは塵が排出され、排気ポートからはガスが排出されます。この時、得られたガスは直接生産に使用することはできず、使用する前にガス内部の塵やタールを除去するために浄化およびフィルタリングが必要です。

精製プロセス

  1. Impurity removing device: The whole set of equipment is equipped with 6 sets of Sacron to ensure the good effect of removing impurities.
  2. Cooling device: The syngas passes through the cold air, condensing the water and tar inside it. In this process, the synthesis gas does not directly contact the air inside the machine but passes through the air duct inside the machine.
  3. Tar filter: The tar filter consists of four tar removers immersed in water.
  4. Tar separator: This machine includes a cooling device, which can make water and tar condense, and then use dry filtration method to discharge tar through centrifugal filtration.
  5. Filter: The inside of the filter contains activated carbon and stainless steel filter screen for the final filtration of tar and water vapor.
  6. Roots blower: Roots blower is the power source of the whole gasification process and purification system. In the whole production process, the role of Roots blower is not only to make the machine run under negative pressure, but also to make the gasification reaction fully, without producing too much carbon dioxide.
バイオマス合成ガスガス化装置の全体構造
バイオマス合成ガスガス化装置の全体構造

バイオマスガス化の原材料要件

  1. 原材料のサイズ:バイオマス粒子またはブロックのサイズは30mmを超えてはいけません。
  2. 原材料の湿度:水分含量は≤20%であるべきです

ビデオ:200kwバイオマスガス化発電所

バイオマスガス化ラインのパラメータ

KX-300SA ガス化装置のパラメータ

合成ガス出力 300m3/h 合成ガスの熱量 1000-1200 kcal/m3
燃料消費 150kg/h 電源供給 380V 50Hz/60H
ガス化効率 >72% ガス化装置の出力 18kw
マッチングエンジン 100kw 原材料 長さサイズは<30mmです、
 要件 水分含量< 20%
証明書 CE 原産地 中国、鄭州
設置サイズ (長さ × 幅 × 高さ)14m×3.5m×5.16m
バイオマスガス化マップ
バイオマスガス化マップ

ガス化装置供給範囲

番号 名前 部品 番号 備考
1 炉本体部品 炉本体 1 ガス化炉
充填機 1 原材料輸送
充填インターフェース 1 マッチング
スクリュー灰排出装置 1 機械的灰除去
灰ホッパー 1 炭灰一時保管
電動バタフライバルブ 4 灰除去装置の閉鎖弁
ビデオオブザーバー 1 ガス化炉室での燃焼の観察
炉心保護プレート 1 安全保護
レベルメーター 2 炉室内の原材料の数と灰ホッパー内の炭灰の量を制御する
温度センサー 3 給餌と灰の除去の制御
鉄のコーン 1 補助材料
2 ダスター サイクロン集塵機 6 合成ガス脱塵
空気冷却ファン 1 冷却
     
     
温度センサー 1 検出温度
3 クーラー クーラー 1 ガス冷却
ファン 1 冷却
4 タール精製器 4セットのタール除去装置と1セットの水冷冷却ガスを含んでいます。 1 タール除去
クーラー 1 循環水冷却
水循環ポンプ 1 冷却水循環
温度センサー 1 検出温度
5 タールフィルター ガス冷却装置 1 冷却合成ガス
タール遠心分離機 1 タール分離
乾燥フィルター 1 フィルタータール
温度センサー 1 検出温度
6 ルーツブロワー ルーツブロワー 1 バイオマスガス化のための電力供給
圧力トランスミッター 1 ルーツブロワの制御
ゴム製ソフト接続 2 衝撃吸収と騒音低減
7 ポリテトラフルオロエチレン製バタフライバルブ   3 合成ガスの輸送制御
8  

 

ガスディストリビューター

乾燥フィルターのセットが3つ含まれています 1 合成ガスのろ過
トーチ 1 合成ガスの品質検出
9 制御キャビネット PLC 1 設備運転の制御システム
10 接続パイプ 溶接   ガス化装置接続
11 ボルトとアスベストパッド     ガス化装置コネクタとシール
12 ホールドオール   1 機器取り付け工具
バイオマスガス化発電所の制御パネル
バイオマスガス化発電所の制御パネル

Genset supply scope

モデル番号(エンジンタイプ) 118D12TL-2
プライムパワー 100KW
定格速度 (r/min) 1500/1800
定格周波数 50Hz / 60Hz
定格電圧 400V/230V
AC 3相、4線
電圧安定性 ≤±1%
電圧トランジェント ≤-10%–+20%
電圧安定時間 ≤3秒
熱消費 ≤11mj/Kw.h
潤滑油消費 ≤1.0g/Kw.h
エンジン容量 151.8 L
シリンダー番号 6-V
シリンダー内径 128mm
ストローク 152mm
始動システム DC 24V 電動モーター
冷却方法 水冷器
潤滑剤方式 受動的および飛行潤滑剤
絶縁クラス H
保護 IP23
オルタネーター 中国スタンフォード
力率 0.8遅れ
励磁方法 ブラシレス
カラー あなたの選択
証明書 ISO 9001:2008, CE
保証 1年または1000稼働時間のいずれか早い方
タイプ オープン
制御システム 自動警報システム
サイズ 2850x1100x1750mm
重量 2350kg

成功事例

ロシアからのお客様が当社の工場を訪れ、技術スタッフとの深い交流を持ちました。

私たちの顧客がバイオマスガス化について議論しています
私たちの顧客はバイオマスガス化について議論しています

 

4.6/5 - (9票)